All UP Express trains taken out of service after cracks found in brake discs
The UP Express airport link is out of service entirely and replaced by Express GO bus service until further notice, a day after it was discovered nearly 80 percent of the fleet had been found to have thermal cracks in brake discs.
The line-wide disruption is due to “unexpected equipment maintenance,” Metrolinx said in a release issued Saturday.
“We are providing an express bus service to Pearson Airport,” the statement reads. “Station Ambassadors are on site to assist.”
Express buses were picking up and dropping off riders on Station Street, and running every 20 mins in both directions on Saturday.
On Friday, most of the fleet servicing the UP Express has been removed from operation after thermal cracks were discovered in the vehicle brake discs, according to the maintenance and operators’ union, leaving Metrolinx with only four train cars in service for the rail link connecting Pearson International Airport to downtown Toronto.
At the time, Metrolinx was adamant the four remaining trains had all passed safety inspections. By 10:30 a.m. on Saturday, they had also been pulled from service.
”Over the course of regular inspections this past weekend, our team discovered hairline cracks in the brake discs on some of our UP Express trains,” Metrolinx said in an emailed statement.
“In the interest of safety, we immediately removed the affected trains from service and proactively inspected the rest of our fleet.”
The general chair of the union representing train operators and maintenance staff tells CTV News the list of questions keep growing, while the assurances to the union have been non-existent that the trains which had been in operation until today had passed inspection.
“There is some relief in terms of the reassurance that everything has been inspected and validated and in good condition,” Gregory Vaughan, General Chairman of Teamsters Canada Rail Conference Division 660. “I would feel a lot more relief if we were able to get a copy of the documents that demonstrate that—certified records that show what was found, or not found as the case may be.”
CTV News has reached out for comment to Alstom, which operates and services the trains under contract to Metrolinx and employs the train operators and maintenance staff.
Metrolinx did not answer questions about the condition of the train cars that had remained in operation until service was cancelled for the entire rail link on Saturday.
The statement on Saturday afternoon said the service had been suspended “due to a technical issue” and not unexpected maintenance, unlike what the Crown corporation told customers in an advisory.
Brake discs are a form of braking system that have been in wide use in motor vehicles, trains, and aircraft for decades, since their invention in the 1890s.
Their life expectancy depends on the materials used, and are routinely serviced and replaced, said mechanical engineer Solomon Boakye-Yiadom, an assistant professor in the Lassonde School of Engineering at York University.
The Toronto Transit Commission (TTC) said it is increasing service to Pearson International Airport for this weekend, specifically its 900 Airport Express bus route, “to provide customers with additional options.”
Buses will operate between Kipling Station and the airport every eight minutes or less, the TTC said.
The 900 Airport Express bus only stops at Kipling Station, Dundas Street West and Acorn Avenue, Dundas Street West and East Mall Crescent, Jetliner Road at Airport Road, Terminal 1 and Terminal 3.
In addition, the TTC said it is also increasing service on the 52A Lawrence West with buses travelling between the airport and Lawrence West subway station.
“These service increases will be in place until end-of-day on Sun. Feb 12. The TTC will continue to monitor passenger volume to determine if airport service will be increased into next week,” the transit agency said in a statement.
The UP Express began operation in 2015.
CTVNews.ca Top Stories
More than 115 cases of eye damage reported in Ontario after solar eclipse
More than 115 people who viewed the solar eclipse in Ontario earlier this month experienced eye damage after the event, according to eye doctors in the province.
Toxic testing standoff: Family leaves house over air quality
A Sherwood Park family says their new house is uninhabitable. The McNaughton's say they were forced to leave the house after living there for only a week because contaminants inside made it difficult to breathe.
Decoy bear used to catch man who illegally killed a grizzly, B.C. conservation officers say
A man has been handed a lengthy hunting ban and fined thousands of dollars for illegally killing a grizzly bear, B.C. conservation officers say.
B.C. seeks ban on public drug use, dialing back decriminalization
The B.C. NDP has asked the federal government to recriminalize public drug use, marking a major shift in the province's approach to addressing the deadly overdose crisis.
OPP responds to apparent video of officer supporting anti-Trudeau government protestors
The Ontario Provincial Police (OPP) says it's investigating an interaction between a uniformed officer and anti-Trudeau government protestors after a video circulated on social media.
An emergency slide falls off a Delta Air Lines plane, forcing pilots to return to JFK in New York
An emergency slide fell off a Delta Air Lines jetliner shortly after takeoff Friday from New York, and pilots who felt a vibration in the plane circled back to land safely at JFK Airport.
Sophie Gregoire Trudeau on navigating post-political life, co-parenting and freedom
Sophie Gregoire Trudeau says there is 'still so much love' between her and Prime Minister Justin Trudeau, as they navigate their post-separation relationship co-parenting their three children.
Last letters of pioneering climber who died on Everest reveal dark side of mountaineering
George Mallory is renowned for being one of the first British mountaineers to attempt to scale the dizzying heights of Mount Everest during the 1920s. Nearly a century later, newly digitized letters shed light on Mallory’s hopes and fears about ascending Everest.
Loud boom in Hamilton caused by propane tank, police say
A loud explosion was heard across Hamilton on Friday after a propane tank was accidentally destroyed and detonated at a local scrap metal yard, police say.