All UP Express trains taken out of service after cracks found in brake discs
The UP Express airport link is out of service entirely and replaced by Express GO bus service until further notice, a day after it was discovered nearly 80 percent of the fleet had been found to have thermal cracks in brake discs.
The line-wide disruption is due to “unexpected equipment maintenance,” Metrolinx said in a release issued Saturday.
“We are providing an express bus service to Pearson Airport,” the statement reads. “Station Ambassadors are on site to assist.”
Express buses were picking up and dropping off riders on Station Street, and running every 20 mins in both directions on Saturday.
On Friday, most of the fleet servicing the UP Express has been removed from operation after thermal cracks were discovered in the vehicle brake discs, according to the maintenance and operators’ union, leaving Metrolinx with only four train cars in service for the rail link connecting Pearson International Airport to downtown Toronto.
At the time, Metrolinx was adamant the four remaining trains had all passed safety inspections. By 10:30 a.m. on Saturday, they had also been pulled from service.
”Over the course of regular inspections this past weekend, our team discovered hairline cracks in the brake discs on some of our UP Express trains,” Metrolinx said in an emailed statement.
“In the interest of safety, we immediately removed the affected trains from service and proactively inspected the rest of our fleet.”
The general chair of the union representing train operators and maintenance staff tells CTV News the list of questions keep growing, while the assurances to the union have been non-existent that the trains which had been in operation until today had passed inspection.
“There is some relief in terms of the reassurance that everything has been inspected and validated and in good condition,” Gregory Vaughan, General Chairman of Teamsters Canada Rail Conference Division 660. “I would feel a lot more relief if we were able to get a copy of the documents that demonstrate that—certified records that show what was found, or not found as the case may be.”
CTV News has reached out for comment to Alstom, which operates and services the trains under contract to Metrolinx and employs the train operators and maintenance staff.
Metrolinx did not answer questions about the condition of the train cars that had remained in operation until service was cancelled for the entire rail link on Saturday.
The statement on Saturday afternoon said the service had been suspended “due to a technical issue” and not unexpected maintenance, unlike what the Crown corporation told customers in an advisory.
Brake discs are a form of braking system that have been in wide use in motor vehicles, trains, and aircraft for decades, since their invention in the 1890s.
Their life expectancy depends on the materials used, and are routinely serviced and replaced, said mechanical engineer Solomon Boakye-Yiadom, an assistant professor in the Lassonde School of Engineering at York University.
The Toronto Transit Commission (TTC) said it is increasing service to Pearson International Airport for this weekend, specifically its 900 Airport Express bus route, “to provide customers with additional options.”
Buses will operate between Kipling Station and the airport every eight minutes or less, the TTC said.
The 900 Airport Express bus only stops at Kipling Station, Dundas Street West and Acorn Avenue, Dundas Street West and East Mall Crescent, Jetliner Road at Airport Road, Terminal 1 and Terminal 3.
In addition, the TTC said it is also increasing service on the 52A Lawrence West with buses travelling between the airport and Lawrence West subway station.
“These service increases will be in place until end-of-day on Sun. Feb 12. The TTC will continue to monitor passenger volume to determine if airport service will be increased into next week,” the transit agency said in a statement.
The UP Express began operation in 2015.
CTVNews.ca Top Stories
B.C. serial killer Robert Pickton dead following prison attack
Convicted B.C. serial killer Robert Pickton, who preyed on women he lured from Vancouver's Downtown Eastside to his rural pig farm, has died.
'We will go with the majority': Liberals slammed by opposition over proposal to delay next election
The federal Liberal government learned Friday it might have to retreat on a proposal within its electoral reform legislation to delay the next vote by one week, after all opposition parties came out to say they can't support it.
Ex-husband charged with murder in death of Lumby, B.C., woman
The ex-husband of Tatjana Stefanski – the woman whose disappearance and death set the small town of Lumby, B.C., on edge last month – has been charged with her murder.
Oilers beat Stars, one win away from Stanley Cup berth
Ryan Nugent-Hopkins scored two power-play goals as Edmonton smothered the Dallas Stars 3-1 to take a 3-2 lead in the NHL's Western Conference final on Friday.
Baby dead after being delivered via emergency C-section to woman who was in police custody
A newborn is dead after being delivered via emergency C-section to a woman in police custody.
Jennifer Lopez cancels summer tour: 'I am completely heartsick and devastated'
Jennifer Lopez has cancelled her 2024 North American tour, representatives for Live Nation confirmed to The Associated Press.
This Calgary home has a giant tree in the middle, and it's for sale
There's a luxury 'tree home' for sale in Calgary.
DND moving 1,000 employees out of Ottawa office building due to safety concerns
The Department of National Defence is moving approximately 1,000 employees out of an office building in Ottawa's Lowertown neighbourhood, citing safety concerns for its employees.
Man convicted of killing Toronto cop in 1980 granted day parole
A man convicted of murdering a Toronto police officer more than four decades ago has been granted day parole for six months.